Material Safety Data Sheet
June 28, 1996
PHONE NUMBERS PHILLIPS 66 COMPANY Emergency: (918) 661-8118 A Division of Phillips Petroleum Company Technical Service: (800) 766-0050 Bartlesville, Oklahoma 74004 For Additional MSDSs: (918) 661-5974 A. Product Identification Synonyms: Phillips ester synthetic compressor oil Chemical Name: Mixture Chemical Family: Ester Chemical Formula: Mixture CAS Reg. No.: Mixture Product No.: 1012886(81720); 1012890(81740); 1012894(81770) Product and/or Components Entered on EPA's TSCA Inventory: YES This product is in U.S. commerce, and is listed in the Toxic Substances Control Act (TSCA) Inventory of Chemicals; hence, it may be subject to applicable TSCA provisions and restrictions. B. Components CAS % OSHA ACGIH Ingredients Number By Wt. PEL TLV The specific chemical identity of this material is being withheld as a trade secret. In accordance with the provisions of 29 CFR Part 1910.1200 (i), it will be provided to a health professional when requested, and/or to a physician or nurse in a medical emergency through utilization of the above Emergency Telephone Number. C. Personal Protection Information Ventilation: Use adequate ventilation to control exposure below recommended levels. Respiratory Protection: If material is heated or aerosalized, use NIOSH/MSHA approved full-face, air supplied respirator operated in a positive pressure or pressure-demand mode. Eye Protection: Use safety glasses with side shields. For splash protection use chemical goggles and face shield. Skin Protection: Use protective garments to prevent skin contact. NOTE: Personal protection information shown in Section C is based upon general information as to normal uses and conditions. Where special or unusual uses or conditions exist, it is suggested that the expert assistance of an industrial hygienist or other qualified professional be sought. D. Handling and Storage Precautions Proper personal protective equipment must be used when handling this chemical. Avoid contact with eyes, skin or clothing. Do not breathe vapor, mist, fume or dust. May be fatal. Use only with adequate ventilation. Wash thoroughly after handling. Launder contaminated clothing before reuse. If pressure injected under the skin, can cause gangrene if not treated. Store in closed containers. Store in well-ventilated area. E. Reactivity Data Stability: Stable Conditions to Avoid: Not Applicable Incompatibility (Materials to Avoid): Oxygen and strong oxidizing agents Hazardous Polymerization: Will Not Occur Conditions to Avoid: Not Applicable Hazardous Decomposition Products: Carbon oxides and various hydrocarbons formed when burned. F. Health Hazard Data Recommended Exposure Limits: No known applicable information. Acute Effects of Overexposure: Eye: Mild irritation. Skin: Mild irritation with prolonged or repeated contact. Inhalation: This material may be highly toxic if inhaled when the product is aerosolized or vapors are inhaled when released during heating. Ingestion: Low oral toxicity. Subchronic and Chronic Effects of Overexposure: No known applicable information. Other Health Effects: Pressurized injection of product under the skin can lead to seriously inflammed tissue. If left untreated, injury can become gangrenous. Health Hazard Categories: Animal Human Animal Human Known Carcinogen ___ ___ Toxic ___ ___ Suspect Carcinogen ___ ___ Corrosive ___ ___ Mutagen ___ ___ Irritant ___ ___ Teratogen ___ ___ Target Organ Toxin ___ ___ Allergic Sensitizer ___ ___ Specify - No known applicable Highly Toxic _X_ ___ information. First Aid and Emergency Procedures: Eye: Flush eyes with running water. If irritation or adverse symptoms develop, seek medical attention. Skin: Wash skin with soap and water. If irritation or adverse symptoms develop, seek medical attention. Inhalation: Immediately remove from exposure. If breathing is difficult, give oxygen. If breathing ceases, administer artificial respiration followed by oxygen. Seek immediate medical attention. Poison! Call a physician. Ingestion: Give two glasses of water and induce vomiting, only if subject is conscious. Seek medical attention. Note to Physician: For injection injuries, immediate medical treatment is required. Physicians may call the emergency number (918) 661-8118. G. Physical Data Appearance: Reddish liquid Odor: Mild Boiling Point: > 450F (> 230C) @ 760 mm Hg Vapor Pressure: 1 mm Hg @ 68F (20C) Vapor Density (Air = 1): Not Established Solubility in Water: Negligible Specific Gravity (H2O = 1): > 0.96 @ 60F (16C) Percent Volatile by Volume: Negligible Evaporation Rate (Butyl Acetate = 1): < 1 Viscosity: 31 - 95 cSt @ 104F (40C) H. Fire and Explosion Data Flash Point (Method Used): > 465F (> 241C) (COC, ASTM D92) Flammable Limits (% by Volume in Air): LEL - Not Established UEL - Not Established Fire Extinguishing Media: Dry chemical, foam or carbon dioxide (CO2) Special Fire Fighting Procedures: Evacuate area of all unnecessary personnel. Shut off source, if possible. Use NIOSH/MSHA approved selfcontained breathing apparatus and other protective equipment and/or garments described in Section C if conditions warrant. Water fog or spray may be used to cool exposed containers and equipment. Fire and Explosion Hazards: Carbon oxides and various hydrocarbons formed when burned. I. Spill, Leak and Disposal Procedures Precautions Required if Material is Released or Spilled: Wear protective equipment and/or garments described in Section C if exposure conditions warrant. Shut off source, if possible and contain spill. Keep out of water sources and sewers. Absorb in dry, inert material. Transfer to disposal drums. Waste Disposal (Insure Conformity with all Applicable Disposal Regulations): Incinerate or otherwise manage at a permitted waste management facility. J. DOT Transportation Shipping Name: Not Regulated Hazard Class: Not Regulated ID Number: Not Regulated Packing Group: Not Regulated Marking: Not Regulated Label: Not Regulated Placard: Not Regulated Hazardous Substance/RQ: Not Regulated Shipping Description: Not Regulated Packaging References: Not Regulated K. RCRA Classification - Unadulterated Product as a Waste Prior to disposal, consult your Environmental contact to determine if TCLP (Toxicity Characteristic Leaching Procedure, EPA Test Method 1311) is required. Reference 40 CFR Part 261. L. Protection Required for Work on Contaminated Equipment Contact immediate supervisor for specific instructions before work is initiated. Wear protective equipment and/or garments described in Section C if exposure conditions warrant. M. Hazard Classification _X_ This product meets the following hazard definition(s) as defined by the Occupational Safety and Health Hazard Communication Standard (29 CFR Section 1910.1200): ___ Combustible Liquid ___ Flammable Aerosol ___ Oxidizer ___ Compressed Gas ___ Explosive ___ Pyrophoric ___ Flammable Gas _X_ Health Hazard (Section F) ___ Unstable ___ Flammable Liquid ___ Organic Peroxide ___ Water Reactive ___ Flammable Solid ___ Based on information presently available, this product does not meet any of the hazard definitions of 29 CFR Section 1910.1200. N. Additional Comments SARA 313 As of the preparation date, this product did not contain a chemical or chemicals subject to the reporting requirements of Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR Part 372. NFPA 704 Hazard Codes - - - - - - - - Signals Least - 0 Health : 1 Slight - 1 Flammability: 0 Moderate - 2 Reactivity : 0 High - 3 Special Haz.: - Extreme - 4